Mini-Max Cleaner

Visit Our Corporate SitePDQ Precision Inc.
(619) 474-3600


AIRCRAFT - Test Results  
GE Electric Brazil View
Gamma Tech Industries, Inc. Materials Test Result

View

STORK Aircraft Wheels Materials Test Results View
Alticor Report View
 
AWARDS & RECOGNITION  
10 Awards and Recognitions from Defense Supply Center, Richmond

View

EPA Approval View
EPA SNAP Program Chart View
SAQMD Award for Technology

View

Clean Air Award View
FDA Registered Class II Device for Cleaning Medical Equipment Doc. #E197753  

 

ELECTRONICS - COMMERCIAL  
Foresite, Inc. Letter

View

Foresite, Inc. Report View
Axsys Customer Letter of Endorsement View
   
 
ENVIRONMENT  
EPA Approval View
EPA SNAP Program Chart View
SAQMD Award for Technology

View

Clean Air Award View
No VOC's - No Solvents - No Waste Water
No Plumbing Needed
 

 

FOOD SERVICE  
 Mahler's Bakery Letter

View

Watch Refrigeration Unit Cleaning Video View
Watch Oven Hood Video View
   
 
MEDICAL  
John Muir Hospital Letter

View

List of Hospital Users View
Chart of Effectiveness on Biohazards View
EPA Approval View

 

NAVY  
NAWC Tech. Report on Steam Cleaning Ejection Seats

View

NELP Report View
Report From Sub Base, Kings Bay, GA View

 

 
PROBLEMS & SOLUTIONS  
Problems and Solutions Documentation

View

   
   

 

WEAPONS ARMAMENT  
Cleaning Platform designed to accomodate the 20mm & 25mm Cannon Barrel

View

Now offering a full line of Bore Cleaning Kits View
Customer Testimonial Amarillo Police Department View
Watch Rifle Cleaning Video View
Watch Small Arms Cleaning Video View

 

 
     
 

 

U.S. NAVY REPORTS

 

U.S. NAVY : FASTT REPORT:

Viable alternative to replace solvent cleaning and degreasing of weapons,

automotive parts, electronics, printed circuit boards, ground support equip. and other gear.

economic analysis: mini-max vs. solvents:

Summary:

Annual savings, Mini-Max $ 383,146

Capital cost: $ 8,324

Payback: Less than one year


NSWC CRANE DIV. REPORT

Evaluation: Hawk (GSE)   Corrosion control program:

Results: ten mother boards & 26 interface cards

cleaned without damage.

Failures due to esd: none

Failures due to excessive heat: none


REPORT: AIMD SAN DIEGO, U.S.  NAVY:

 

Cleans a myriad of small parts that heretofore deemed difficult if not virtually impossible to clean.

 


 

NAF EL CENTRO, CA TEST RESULTS:

Waste management:  Disposal costs normally: 4 drums aircraft cleaner / water: in 2 weeks cost $360.00.

With Mini-Max waste disposal system reduced to two pig mats, disposal cost about .80 cents every two weeks.

Parts cleaned: Time cut from 4 hours to 1 .5 hrs per 100 parts and cleaned far better than by hand.

No soaking, we cleaned immediately.

Aircraft cleaner eliminated.

Mini-Max water usage rate:1 gal per 8 hours of continuous cleaning.


 

P2 MESSAGE (FASTT)  U.S.N. :

P-2 pollution opportunity identified:

Mini-Max System replaces solvent cleaning in degreasing. The technology uses distilled water.

Compared to current cleaning procedures this technology saves labor and associated costs.

Study: Sub base Bangor: This technology reduces time to clean circuit boards by 90 hrs a month, estimated savings 9k a yr.

Unit paid for itself in  6 mos.


 

U.S. AIR FORCE REPORTS

 

MALSTROM  AFB:

341LSS/LGLR : RIVET MILE WING 1:

We clean small and large shock absorbers from 1 to 4 ft. long, cleaning ports inside and out as well as the grooves.

We remove oil, grease, corrosion.

We broke away from hazardous solvents completely.

 


 

U.S.  AIR FORCE MEEP:

Report: Ground equipment.

Conclusion: Performed extremely well.

Properly cleaned majority of parts without removal, reach inaccessible areas; no dangerous chemical cleaners used.

Final action: Mini-Max Cleaners will be recommended for Air Force use.

 


 

 

U.S.M.C. REPORTS

 

U S M C : PAX RIVER TO ASST DPTY. SEC/NAVY

SAFETY AND SURVIVABILITY:

The Marines were impressed - cut work time in half. Arma-Sol rust inhibitor helped prevent weapons from rusting.

Result: more constructive training schedule.

 

EVALUATION MARINES:

Cleaning their weapons has never been easier. Entire inventory of weapons now cleaned in days not weeks.

 


 

 

U.S. ARMY REPORTS

 

TOBYHANNA ARMY DEPOT:

 

The Mini-Max is used to clean printed circuit boards, power supplies, rack wiring, harnesses, cables, modules, chassis hardware, test sets transponder and interrogator sets etc.

It has proved to be environmentally safe and a time saver.

Home :: Our Mission :: See It In Action :: Products :: Medical Products :: Documentation :: Feedback :: PDQ Precision, Inc.

PDQ Precision, Inc.
1433 Roosevelt Avenue • National City, CA 91950
Plant: (619) 474-3600 • Fax: (619) 474-1300

Copyright © 2013 PDQ Precision Inc.
Privacy Policy